Technical description and composition of the MYSTERY MTV-2419LW TV, type of panel and applicable modules. The composition of the modules.MYSTERY LED
Model: MTV-2419LW
Chassis / Version: 40-OMS82D-MAD2LG
Panel: LC230EUE (SE) (A1)
LED driver (backlight): integrated into PSU
Power Supply (PSU): PLE50P
MainBoard: 40-OMS82D-MAD2LG - OLQ109373B
IC MainBoard: Spi Flash: W25Q32BV, Sound: MSH9010-LF
Tuner: XF-3SA
Technical Specifications MTV-2419LW
MYSTERY MTV-2419LW
General repair guidelines for TV LCD LED
Possible manifestations of defects
- The MYSTERY MTV-2419LW TV does not turn on at all. There is no reaction to the remote control or to the control buttons from the front panel. Indicator lights do not light or flash.
With such manifestations, in most cases, the PLE50P power module is faulty. It is necessary to verify the presence of secondary voltages and, if they are absent, check the power switches and rectifier diodes for a probable short circuit.
In case of breakdowns in the secondary circuits, the converter can emergencyly operate in the short circuit mode, and during short circuit in the power elements of the primary circuit, the mains fuse usually breaks.
The breakdown of Mos-Fet keys used in pulsed sources is often caused by malfunctions of other elements, for example, power supply, frequency-setting, damper ... as well as elements of the Negative Stabilization Feedback. The PWM chip can also cause a malfunction of the power switch of the converter and is checked by replacement.
- There is no image, there is sound, it is responding to the remote control. Or immediately after turning on for a second, the image may appear and immediately disappear.
A malfunction is usually most likely in these cases at the backlight nodes of the display matrix. The reason can be both in the power supply of the LEDs, in their serviceability (breakdown or breakage), as well as in the violation of the contact connections of the LED strips.
When trying to detect a break in the LED lines, it should be taken into account that it is difficult to do this without disassembling the panel. For example, a current source is needed to open PN junctions connected in series.
- The indicator blinks or lights constantly, the TV does not turn on, does not respond to the remote control.
In the absence of tuning to the channels of on-air or cable television, you should make sure that the software is correct, as well as in accordance with the ratings of the supply voltage at the terminals of the XF-3SA tuner. It is also necessary to check the presence of pulses of data exchange between the tuner and the processor via the I2C bus using an oscilloscope.Repair or diagnostics of the 40-OMS82D-MAD2LG motherboard should begin by checking the stabilizers and power converters needed to power the chips and matrix. If necessary, update or replace the software (software). Complex repair of MB (SSB) is possible only in the conditions of a service center with the necessary equipment. Checking or replacing Spi Flash elements: W25Q32BV, Sound: MSH9010-LF requires the necessary training and professional skills to repair modules at the component level. Problems associated with the use of BGA soldering technologies can sometimes be diagnosed by warming up.
Attention! Users and owners of MTV-2419LW TVs who do not have the appropriate qualifications, knowledge and experience are strongly advised against self-repair attempts in order to avoid negative consequences that could lead to complete non-repairability of the device.
Repair MainBoardThe appearance of the MainBoard 40-OMS82D-MAD2LG is shown in the figure below:
40-OMS82D-MAD2LG
40-OMS82D-MAD2LG can be used in TVs:
MYSTERY MTV-2419LW (Panel LC230EUE (SE) (A1)), MYSTERY MTV-3212W (Panel LVW320CSOT C1).
The appearance of the power supply
Main features of the MYSTERY MTV-2419LW device:
Installed matrix (LED panel) LC230EUE (SE) (A1).
To power the backlight LEDs, a converter is used, combined with a power supply.
The formation of the necessary supply voltages for all nodes of the MYSTERY MTV-2419LW TV is carried out by the PLE50P power module, or its analogs.
MainBoard - the main board (motherboard) is a 40-OMS82D-MAD2LG module, using Spi Flash chips: W25Q32BV, Sound: MSH9010-LF and others.
The XF-3SA tuner provides TV reception and channel tuning.
Additional technical information about the panel:
Brand: LG Display
Model: LC230EUE-SEA1
Type: a-Si TFT-LCD, Panel
Diagonal size: 23.0 inch
Resolution: 1920x1080, FHD
Display Mode: S-IPS, Normally Black, Transmissive
Active Area: 509.184x286.416 mm
Surface: Antiglare (Haze 10%), Hard coating (3H)
Brightness: 250 cd / m²
Contrast Ratio: 1000: 1
Display Colors: 16.7M (6-bit + Hi-FRC)
Response Time: 5 (G to G)
Frequency: 60Hz
Lamp Type: 17S2P WLED Without Driver
Signal Interface: LVDS (2 ch, 8-bit), 30 pins
Voltage: 5.0V
TV MYSTERY MTV-2419LW with LCD display LC230EUE, diagonal size 24 "(61 cm) 16: 9 format. The required brightness of the screen 250 cd / m² is provided by LED backlight LED. Contrast, as the ratio of maximum brightness to minimum, is 4000: 1. The LED-panel of this TV has an end LED backlight - Edge LED.The design and technical capabilities of the TV include watching programs and movies in high quality HD at a resolution of 1920x1080 pixels in a graphic layout according to the standard 1080p (Full HD). Audio or video signal can be processed in analogue systems PAL, SECAM, NTSC. Graphic processing and digital signal generation occurs in standards 480i, 480p, 576i, 576p, 720p, 1080i. Supported media file formats: MP3, WMA, MPEG4, DivX, MKV , JPEG.
The power of the acoustic system of sound 6 W (2x3 W) provide two speakers. The audio processing system NICAM STEREO is used.
The external interface (communication with other devices) is supported by standard input and output connectors: antenna input (RF), AV, audio x2, S-Video, component, SCART, RGB, VGA, HDMI x3, USB. To connect a computer or laptop to this TV model, a VGA (D-Sub 15) connector is used on the TV case, this interface supports resolutions: 640x480, 800x600, 1024x768.
The power consumed by the TV in the operating mode from the network is 40 watts.
Dimensions: With stand 642x444x209 mm, Without stand 570x345x70 mm.
Attention! The LC230EUE (SE) (A1) panel of the MYSTERY MTV-2419LW LED TV is an expensive and unreliable element.
Avoid any impact on the glass and pressure on the surface of the screen to avoid damage to the LED panel!
It is also unsafe to get liquid on the screen. Sometimes one drop is enough if it flows down the glass onto the cables so that the TV becomes unrepairable.