Technical description and composition of LG 55LB675V TV, type of panel and modules used. Module composition.
Composition
Specifications
LG 55LB675V
Smart TV 3D 55LB675V | Year of manufacture: 2014
Screen diagonal: 55" (140 cm)
Screen format: 16:9
Resolution: 1920x1080
Frequency refresh rate: 200 Hz
LED backlighting: yes, Direct LED
Smart: yes. Wi-Fi support: yes
3D support: yes, polarization technology, 2D to 3D conversion
Support HD: 1080p Full HD
Viewing angle: 178°
Progressive scan: yes
TV Standards: PAL, SECAM, NTSC
Digital tuner: DVB-T, DVB-T2, DVB-C, DVB-S2
Teletext: 2000 page memory.
DTV formats: 480i, 480p, 576i, 576p, 720p, 1080i, 1080p
Multimedia: MP3, WMA, MPEG4, DivX, MKV, JPEG
Audio Stereo: Yes
Sound power: 24W
Acoustics: 3 speakers
Interface: AV, audio x2, component, SCART, RGB, HDMI x3, MHL, USB x3, Ethernet (RJ-45), Bluetooth, Wi-Fi 802.11n, WiDi, Miracast
Headphone jack: Yes
Dimensions: With stand 1230x767x247mm
Without stand 1230x709x55mm
LG LED
Model: 55LB675V
Chassis/Version: LD42B
Panel: LC550DUH (PG)(F1)
LED backlight: Direct LED 3V
LED driver (backlight): integrated into PSU
PWM LED driver: iW7025-00
Power Supply (PSU): EAX65424001 (2.4) LGP55K-14LPB
PWM Power: MAP8800 (PFC), CP1034DG, ICE3BR4765JZ
MOSFET Power: 13N60M2
MainBoard: EAX65384003 (1.2) EBR78615101
IC MainBoard: CPU: LG1311; DRAM: H5TQ4G63AFR-PBC; EEPROM: AT24C256C, EMMC: THGBMAG6A2JBAIR
TDJM-G101D
General advice about LCD LED TV repair
Possible problems
- LG 55LB675V TV does not turn on. There is no sign of any function. The indicators on the front panel do not light or blink, the TV does not respond to the control buttons.
In some of these cases, the fault is found in the power module EAX65424001. Then we recommend to measure its output voltages, and if not, check the serviceability of the power switches (13N60M2) and the rectifier diodes of the converters for possible short circuits.
If there is a breakdown in the secondary circuits, the inverter can usually be short-circuited, and if there is a short in the primary circuit power elements, the mains fuse or the current sensor at the source of the switch will most often blow.
Breakdown of Mos-Fet switches used in pulse sources is often caused by failures of other elements, for example, in PWM regulator supply circuit, in frequency-retaining or damping circuits, as well as in the Negative Feedback Stabilization. PWM chips MAP8800 (PFC), CP1034DG, ICE3BR4765JZ are usually checked by replacement with new ones or with known good ones.
If the LG 55LB675V has no picture, but there is sound, often the display backlight of the LC550DUH (PG)(F1) simply does not work. Moreover, in LED-TVs usually fail LEDs inside the panel, less often the LED-driver.
In such cases you can see faintly visible image when external light hits the screen.
To replace the LEDs requires disassembly LCD-panel LC550DUH - the process requiring a master of experience and expertise. We do not recommend to perform such works by yourself to owners of TV sets and masters who have no experience in LCD-panel repair.
READ HOW TO REPAIR THE TV LED BACKLIGHT --------------> HERE.
If there is no image, but backlighting works - the screen becomes slightly lighter when the TV is turned on, and in the open TV you can see the light through the holes in the body of the panel.
In this case the panel may be defective - damage to the strips, cables, for example, as a consequence of moisture after an unsuccessful washing of the screen, the T-CON board (Timing Controller) may be defective. But quite often the MainBoard EAX65384003 is defective, and software failure is also possible.
Then first it is necessary to check the panel supply voltage, fuses on the T-CON board, as well as the supply and reference voltages of the column and line drivers - VGH, VGL, Vcom.
If these measurements are within normal limits, it is necessary to trace by oscilloscope the LVDS signals from MainBoard EAX65384003, as well as synchronizing signals to the driver stubs.
Filled or unsuccessfully washed LED TV screens can be restored in about half of the cases, usually, if there was not significant damage in the cables and panel bars.
- No picture, but there is sound and reaction to the remote control. Or for a second the image can appear immediately after turning on.
Often in such cases there is no backlighting of the LED panel. The cause may be found in the malfunction of LEDs, in violation of the contact connections of the Direct LED 3V, or in their power supply (LED-driver).
It is better to use a power supply with a maximum voltage of 200V to check if the LEDs are faulty. It is not recommended to use any voltage sources for this purpose. You can check each LED individually with a simple Chinese multimeter (9 volt) in P-N junction mode. If you connect the red probe of the multimeter to the anode of the LED and the black to its cathode, then the 3 volt LED will light up slightly and in the opposite direction you will find the faulty junction of the stabilizer. The functionality of the PN junction of the stabilizer is indirectly an indication of the functionality of the LED.
READ HOW TO REPAIR THE TV LED BACKLIGHT --------------> HERE.
- LED blinks or lights constantly, TV set does not turn on, remote control is unresponsive.
Repair or diagnostic of motherboard EAX65384003 should be started with checking stabilizers and power converters necessary to power the chips and matrix. If necessary, the software (software) should be updated or replaced. In some cases to repair MB board (SSB) you may need to replace CPU: LG1311; DRAM: H5TQ4G63AFR-PBC; EEPROM: AT24C256C, EMMC: THGBMAG6A2JBAIR with new or known good ones. In cases of BGA technology, defects are usually localized by the heating method.
The TDJM-G101D tuner malfunction is detected after checking the software and all the supply voltages on its pins. The data exchange between the tuner and the CPU via I2C bus can be checked with an oscilloscope.
Remember! Attempts to repair TV LG 55LB675V, in the absence of the necessary skills and experience, categorically not recommended and are fraught with negative consequences, up to complete BROKEN device!
DOWNLOAD SCHEMATIC DIAGRAM / SERVICE MANUAL ------------------> Chassis: LD42B 55LB670V, 55LB671V, 55LB673V, 55LB675V, 55LB679V -Z*. 55LB670V, 55LB671V, 55LB673V, 55LB675V,
55LB679V -Z*.
DOWNLOAD SCHEMATIC DIAGRAM / SERVICE MANUAL ------------------>CHASSIS : LD42B 55LB700V, 55LB700V-ZG, 55LB670V, 55LB671V, 55LB673V, 55LB675V, 55LB679V.
Refinement after repair of the backlight. EAX65424001, iW7025-00. Information from the master.
Reduce backlight current from 220 mA to 150 mA - I replaced 1.5 Ohm resistors R805, 808, 811, 814, 817, 820, 823, 832, 838, 841, 844 with 2.2 Ohm in each LED driver channel current sensors on EAX65424001 power supply board.
Driver current limiting. EAX65424001, iW7025-00. General information.
To decrease the backlight current in TV's with EAX65424001 power supply and iW7025-00 LED driver controller, you can increase the ratings of the resistors (current sensors) in the ON/OFF switch of each channel.
EAX65424001 current backlight
More on MainBoard Repair
The exterior of the EAX65384003 MainBoard is shown in the figure below:
EAX6538384003
The EAX65384003 can be used in televisions:
LG 47LB650V ZE (Panel LC470DUH (FG) (P2)), LG 42LB631V ZL (Panel LC420DUH (FG) (A1)), LG 39LB650V (Panel T390HVJ01.2), LG 55LB673V ZB (Panel LC550DUH (PG)(F1)), LG 47LB677V (Panel LC470DUH (FG)(F1)), LG 42LB673V (Panel LC420DUH (PG)(F1)), LG 47LB673V (Panel LC470DUH (PG)(F1)), LG 32LB652V 32LB652V-ZA.BRUWLDU (Panel LC320DUH (FG)(P2)), LG 50LB653V (Panel LC500DUH (FG)(P1)), LG 42LB652V 42LB652V-ZA.BRUWLJU (Panel LC420DUH (FG)(P2)), LG 55LB720V 55LB720V-ZG.BRUWLJU (Panel LC550DUH (PG)(F1)).
The main features of the LG 55LB620V-ZG BRUWLJU
The main features of the LG 55LB675V device:
The matrix (LED panel) LC550DUH (PG)(F1) is installed.
Converter combined with the power supply is applied for powering of backlight LEDs, controlled by PWM controller iW7025-00.
The power supply module EAX65424001 or its analogues with the use of such microcircuits as MAP8800 (PFC), CP1034DG, ICE3BR4765JZ and power keys of 13N60M2 type perform the formation of the necessary supply voltages for all LG 55LB675V TV assemblies.
MainBoard - the main board (motherboard) is a module EAX65384003, with the use of chip CPU: LG1311; DRAM: H5TQ4G63AFR-PBC; EEPROM: AT24C256C, EMMC: THGBMAG6A2JBAIR and others.
The TDJM-G101D tuner provides television program reception and channel tuning.
More technical information about this panel:
Brand : LG Display
Model : LC550DUH-PGF1
Type : A-Si TFT-LCD, Panel
Diagonal size : 55 inch
Resolution : 1920x1080, FHD
Display Mode : IPS, Normally Black, Transmissive
Active Area : 1209.6x680.4 mm
Surface : Antiglare (Haze 1%), Hard coating (2H)
Brightness : 450 cd/m²
Contrast Ratio : 1400:1
Display Colors : 16.7M (8-bit), CIE1931 72%
Response Time : 8/10 (Tr/Td)
Frequency : 120Hz
Lamp Type : WLED Without Driver
Signal Interface : EPI, 100 pins
Voltage : 12.0V
Display technologies: 1920 x 1080 (Full HD). The backlight type is Direct with local dimming. Motion Clarity Index (MCI) 700. Cinema Screen design.
Picture Technologies: Triple XD Processor; Local Contrast Optimizer; Tru Black Control; Interpolation capability (up to FULL HD); Dynamic Color Control; Picture Wizard support; HEVC support - 2K HEVC 60P; H.264 support - 2K H.264 30P.
3D Technologies: FPR (polarization). Cinema 3D; Auto format detection. 2D to 3D conversion. 3D depth control: 0~+20 (default 10). Change 3D viewpoint: - 10~+10 (default: 0). Dual Play (Dual Play on 1 screen), Dual Play glasses are sold separately.
Audio technologies: Dolby Digital decoder; Clear Voice II function; DTS decoder; Subwoofer; Sound output power S/N : 12W + 12W; Audio codecs - AC3(Dolby Digital), EAC3(DDP), AAC, AAC HE, MPEG-1 Layer I&II, MP3, PCM, DTS.
Sound modes: 6 modes (Standard, Music, Movie, Sports, Game, User)
Picture modes: 8 modes (Bright, Standard, Cinema, Sport, Game, Eco-mode, Expert-1, Expert-2)
Features Smart: Smart TV WebOS; Full Web Browser; Skype with camera and microphone as a set, the application store; Premium content as a gift; 3D World Collection; Search for Smatr-content and the Internet, display the content from other devices Smart Share;
Wireless: Miracast data transmission. Supports Near Field Communication (NFC) wireless technology. Wireless content transfer technology Wireless Display (WiDi). Supports WiFi Direct. Magic Motion remote control. Voice typing.
Input and output connectors (wired interface): CI slot side (vertical)1; HDMI 1.4 rear panel 3; Composite input (CVBS + Audio)1 (H, Sharing with Component); Component input (Y,Pb,Pr) + Audio(Y,Pb,Pr) + Audio1; Scart (Full) 1; LAN (Internet access DLNA) 1; Digital audio output (optical) 1;
LG 55LB675V TV with LC550DUH (PG) (F1) LCD display, measuring 55" (140 cm) diagonally in 16:9 aspect ratio. In the LCD-panel the principle of direct display backlighting with a rear arrangement of LEDs - Direct LED is implemented.
There is support of 3D image using passive polarization technology.
LC550DUH matrix and MainBoard software EAX65384003 provide for viewing shows and movies in HD quality at 1920x1080 pixels in 1080p (Full HD) resolution.
The 55LB675V is equipped with SMART software, built-in applications and Internet connectivity. Connection to the network can be made through Wi-Fi wireless communication. The input analog video signal is decoded in PAL, SECAM, NTSC. Graphical processing of a digital signal is done in 480i, 480p, 576p, 720p, 1080i, 1080p. Supported media file formats: MP3, WMA, MPEG4, DivX, MKV, JPEG.
The sound system capacity of 24 W is provided by 3 speakers. NICAM stereo sound processing system and Sound Surround surround function are used.
Communication with other devices via an external interface is supported by standard inputs and outputs: Antenna Input (RF), AV, Audio x2, Component, SCART, RGB, HDMI x3, MHL, USB x3, Ethernet (RJ-45), Bluetooth, Wi-Fi 802.11n, WiDi, Miracast. There is a headphone jack. A VGA (D-Sub 15) connector is provided to connect a computer or laptop to this TV model. This interface supports standard resolutions: 640x480, 800x600, 1024x768, 1280x1024, 1360x768, 1920x1080. The digital tuner is able to receive TV channels in the standards DVB-T, DVB-T2, DVB-C, DVB-S2.
The TV uses the EAX65424001 power supply.
Dimensions: C stand 1230x767x247 mm, No stand 1230x709x55 mm.
Warning. The panel of LC550DUH LED TV LG 55LB675V is an expensive and unreliable part of it.
Do not allow any impact on the glass and pressure on the surface of the screen to avoid damage to the LED panel!
It is also not safe to get liquid on the screen. Sometimes one drop is enough if it drips down the glass onto the cables and the TV becomes unrepairable.
