Technical description and composition of the LG 55LA662V TV, panel type and applicable modules. The composition of the modules.LG
Model: 55LA662V
Panel: LC550EUH (PF) (P1)
Inverter (backlight): integrated into PSU
Power Supply (PSU): EAX64905801 (1.9) LGP55-13LPB
MainBoard: EAX64797003 (1.2) EBR76823179
IC MainBoard: CPU: LGE2122, H5TQ4G63AFR x2, H5TQ2G63AFR, NTP7513
Tuner: TSQ-G601D (B) EBL61240503
Control: Remote: AKB73715601
Technical Specifications 55LA662V
LG 55LA662V
General recommendations for repairing TV LCD
Possible malfunctions
- The LG 55LA662V TV does not turn on and does not show any signs of turning on, does not respond to the control buttons or to the remote control.
With such manifestations, in some cases, the EAX64905801 power module is faulty. Then it is necessary to measure its output voltages and, in case of their complete or partial absence, it is necessary to check the serviceability of power switches and rectifier diodes of the converters for a possible short circuit.
In case of any breakdown of semiconductors in the secondary circuits, the converter can usually work normally in emergency short circuit mode. There are no output voltages. And with a short circuit in the power elements of the primary circuit, as a rule, the mains fuse breaks and less often the current sensor at the source of the key.
Mos-Fet keys used in switching power supplies usually fail due to a malfunction of other elements that can put it out of operation in key mode or provoke an excess of the maximum current or voltage. These can be circuits supplying the PWM controller, damping or frequency-setting circuits, or elements of OOS (negative feedback) in the stabilization circuit. PWM controllers (PWM), in the absence of external damage and short circuit between the terminals, are checked by replacing with obviously good ones.
- There is no image, there is sound, it responds to the remote control. Or the image may appear for a second when turned on and immediately disappears.
The defect can be caused by problems in the nodes or elements of the backlight of the display, or in the power supply of the lamps or inverter. If all the electrolytic capacitors of the filter according to the power supply of the inverter are working, make sure that the lamps are working, then you need to check the converter keys and the secondary windings of the transformers.
If in diagnosing a malfunction, it is necessary to disable the inverter protection, there is a risk of failure of the power elements of the inverter, and special care is required during work, and after their completion, it is necessary to restore the protection circuits for further safe operation of the TV by the owner in normal mode.
- The indicator on the front panel blinks, the TV does not turn on in operating mode, it does not respond to the remote control.
Repair or diagnostics of the EAX64797003 motherboard should begin by checking the stabilizers and power converters needed to power the chips and matrix. If necessary, update or replace the software (software). In cases of attempts to repair the MB (SSB) board, it is necessary to check the health of its elements - CPU: LGE2122, H5TQ4G63AFR x2, H5TQ2G63AFR, NTP7513 which may require replacement with new ones. If a BGA processor is installed, there is a possibility of a violation of the soldering of the contacts of its conclusions with the board (it is diagnosed by heating).
In the absence of tuning to the channels of on-air or cable television, you should make sure that the software is correct, as well as in accordance with the ratings of the supply voltage at the terminals of the TSQ-G601D (B) EBL61240503 tuner. It is also necessary to check the presence of pulses of data exchange between the tuner and the processor via the I2C bus using an oscilloscope.
It should be remembered! Attempts to independently repair the LG 55LA662V TV, in the absence of the necessary qualifications and experience, are categorically not recommended and are fraught with negative consequences, up to the complete non-repairability of the device!
The appearance of the MainBoard EAX64797003 is shown in the figure below:EAX64797003
EAX64797003 can be used in TVs:
LG 42LA620V (Panel LC420DUE (SF)(U1)), LG 32LN570V (Panel LC320DUE (SF)(R1)), LG 50LA644V (Panel LC500EUN (SF)(F1)), LG 47LA660V (Panel LC470EUG (PF)(F1)), LG 47LA621V (Panel LC470DUE (SF)(U1)), LG 42LA644V (Panel LC420EUN (SF)(F2)), LG 39LA620V ZA (Panel T390HVJ01.0), LG 42LA621V ZD (Panel LC420DUE (SF)(U1)), LG 32LA621V ZD (Panel LC320DUE (SF)(U1)), LG 32LN655V (Panel LC320EUB (PF)(M1)), LG 42LA667V (Panel LC420EUH (PF)(P1) ), LG 47LN613V (Panel LC470DUE (SF)(R4)), LG 32LA667V ZB (Panel LC320EUB (PF)(P1)), LG 55LA660V ZA (Panel LC550EUH (PF)(P1)), LG 47LA620V ZA (Panel LC470DUE (SF)(U1)), LG 32LN613V ZB (Panel LC320DUE (SF)(R4)), LG 42LN655V ZB.BRUZLJU (Panel LC420EUH (PF)(M1)), LG 32LA644V ZA (Panel LC320EUN (SF)(F1)), LG 42LN613V (Panel LC420DUE (SF)(R4)), LG 47LA690V ZB (Panel LC47EUH (PF)(P1)), LG 47LA662V (Panel LC470EUG (PF)(F1)), LG 42LA645V 42LA645V-ZC.BRUYLJU (Panel LC420EUN (SF)(F3)), LG 32LA660V (Panel LC320EUB (PF)(P1)), LG 47LA644V 47LA644V-ZA (Panel LC470EUN (SF)(F2)), LG 50LA667S (Panel T500HVD02.1), LG 47LA691V (Panel LC470EUH (PF)(P1)), LG 32LA662V (Panel LC320EUB (PF)(P1)).
The appearance of the power supply
Main features of the device LG 55LA662V:
Installed matrix (LCD panel) LC550EUH (PF) (P1).
To power the backlight, a converter is used, combined with a power supply.
The formation of the necessary supply voltages for all nodes of the LG 55LA662V TV is carried out by the EAX64905801 power supply module or its analogs.
MainBoard - the main board (motherboard) is an EAX64797003 module using CPU chips: LGE2122, H5TQ4G63AFR x2, H5TQ2G63AFR, NTP7513 and others.
The tuner TSQ-G601D (B) EBL61240503 provides the reception of television programs and tuning to channels.
