Technical description and composition of the TCL 40D3200 TV, type of panel and applicable modules. The composition of the modules.TCL LED
Model: 40D3200
Chassis / Version: MS82
Panel: LTA400HM13
Power Supply (PSU): PE421C5
PWM Power: FSL206MR, FAN7930C, FSFR1700XS
MOSFET Power: K12A50D
MainBoard: 40-MS82S0-MAD2XG
IC MainBoard: MST6E182VS-LF, 25Q32A-100HIP, 24C64, K4T51163QT-BCF7, IT6633E-P, TPA3110D2
Tuner: F35WT-3-E 07-380F15-NK4G
Specifications 40D3200
TCL 40D3200
General repair guidelines for TV LCD LED
Possible malfunctions
- The TCL 40D3200 does not turn on. There are no signs of operability. The indicators on the front panel do not light or flash, the TV does not respond to the remote control and control buttons.
In some of these cases, a fault is detected in the PE421C5 power supply module. It is necessary to measure its output voltages and, if they are absent, check the operability of power switches (K12A50D) and rectifier diodes in the converters for possible breakdown.
In case of breakdowns of semiconductors in the secondary circuits of any converter, as a rule, it can operate in emergency short-circuit mode without output voltages, and during short circuit in the elements of the primary circuit, the main fuse and, less often, the current sensor at the source of the key are most often cut off.
Mos-Fet keys used in switching power supplies usually fail due to a malfunction of other elements that can put it out of operation in key mode or provoke an excess of the maximum current or voltage. These can be circuits supplying the PWM controller, damping or frequency-setting circuits, or elements of OOS (negative feedback) in the stabilization circuit. PWM controllers (PWM) FSL206MR, FAN7930C, FSFR1700XS, in the absence of external damage and short circuit between the terminals, are checked by replacing with obviously good ones.
- There is no image, there is sound, it is responding to the remote control. Or immediately after turning on for a second, the image may appear and immediately disappear.
Often in such cases, there is no LED backlight. The reason can be both in the power supply of the LEDs, in their serviceability (breakdown or breakage), as well as in the violation of the contact connections of the LED strips.
When trying to detect a break in the LED lines, it should be taken into account that it is difficult to do this without disassembling the panel. For example, a current source is needed to open PN junctions connected in series.
- The indicator on the front panel blinks, the TV does not turn on in the operating mode, it does not respond to the remote control.
Repair or diagnostics of the 40-MS82S0-MAD2XG motherboard should begin by checking the stabilizers and power converters needed to power the chips and matrix. If necessary, update or replace the software (software). If it is not possible to replace the MB (SSB) card, you need to check the health of its elements - MST6E182VS-LF, 25Q32A-100HIP, 24C64, K4T51163QT-BCF7, IT6633E-P, TPA3110D2. Defective components should be replaced.
If a tuner F35WT-3-E 07-380F15-NK4G is suspected of malfunction, first of all, it is necessary to verify the correctness of the software, as well as the presence of the necessary power supply voltage levels and data exchange pulses with the processor via the I2C bus at the corresponding tuner pins.
Once again, remind users! Attempts to independently repair the TCL 40D3200 TV without the appropriate qualifications and necessary experience can lead to its complete non-repairability!
FIRMWARE FOR SPI FLASH -----------> TCL 40D3200 MS82, Main: 40-MS82S0-MAD2XG , Panel: LTA400HM13
The appearance of the MainBoard 40-MS82S0-MAD2XG is shown in the figure below:40-MS82S0-MAD2XG
40-MS82S0-MAD2XG can be used in TVs:
ERISSON 23LET70 (Panel LTA230AP01), GOLDSTAR 32A340R (Panel LVW320SSTM E1), GoldStar LT-42A320F (Panel LVF420AUBK), MYSTERY MTV-3225LW (Panel LVM320CSTME13V4), MYSTERY MTV-4019LW (Panel LVF390CMTM E13 V5), MYSTERY MTV-3219LW (Panel LVW320CSTME18 V2), TCL 40D3200 (Panel LTA400HM13 ), TCL 39D3320 39D3320F (Panel LVF390CMTM E13 V2), TCL 39E5000F3D (Panel V390HK1-LS5), THOMSON T39ED33HU (Panel LVF390CMTME15V2), THOMSON T32ED33U (Panel LSC320AN01-C06), THOMSON T32E32U (Panel LVW320SSTT E1).
The appearance of the power supply
Main features of the TCL 40D3200 device:
Installed matrix (LED-panel) LTA400HM13.
The necessary supply voltages for all nodes of the TCL 40D3200 TV are generated by the PE421C5 power module or its analogs using FSL206MR, FAN7930C, FSFR1700XS microcircuits and K12A50D type power switches.
MainBoard - the main board (motherboard) is a 40-MS82S0-MAD2XG module, using microcircuits MST6E182VS-LF, 25Q32A-100HIP, 24C64, K4T51163QT-BCF7, IT6633E-P, TPA3110D2 and others.
The tuner F35WT-3-E 07-380F15-NK4G provides the reception of television programs and tuning to channels.
The TCL 40D3200 TV with an LTA400HM13 LCD display, 40 "(102 cm) diagonal size in 16: 9 format. The brightness of the screen declared by the manufacturer, 380 cd / m², is realized by LED backlight. The LCD panel of this TV has LED backlight - Edge LED: Design and technical capabilities of the TV provide viewing of broadcasts and films in high quality HD with a resolution of 1920x1080 pixels in graphic resolution according to the standard 1080p (Full HD). The input high-frequency or video signal can be processed in analogue systems PAL, SEC AM, NTSC. Graphic processing and digital signal generation occurs in the standards 480i, 480p, 576i, 576p, 720p, 1080i, 1080p. Supported media file formats: MP3, MKV, JPEG.
The power of the sound system 10 W (2x5 W) provides two speakers. The audio processing system NICAM STEREO is used.
The external interface (communication with other devices) is supported by standard input and output connectors: antenna input (RF), HDMI x3, USB. An output for connecting headphones is provided. To connect a computer or laptop to this TV model, a VGA (D-Sub 15) connector is used on the TV case, this interface supports resolutions: 640x480, 800x600, 1024x768, 1280x1024, 1360x768, 1920x1080.
A digital tuner is capable of receiving television channels in the DVB-T MPEG4, DVB-C standards.
Overall dimensions: 987x692x267 mm.
TV mass: with stand: 15 kg, without stand: 14 kg.
Attention! The LTA400HM13 panel of the TCL 40D3200 LED TV is an expensive and unreliable element.
Avoid any impact on the glass and pressure on the surface of the screen to avoid damage to the LED panel!
It is also unsafe to get liquid on the screen. Sometimes one drop is enough if it flows down the glass onto the cables so that the TV becomes unrepairable.
